全自動攪拌車使用十大安全操作事項
每個行業都有自己需要注意的事情，尤其是駕駛那種車型非常高大的汽車，更是有很多需要注意的事情。對此，全自動攪拌車廠家就說說在開攪拌車的時候，有哪些方面需要注意呢？
Every industry has its own things to pay attention to, especially when driving a very tall car, there are many things to pay attention to. In this regard, the full-automatic mixer manufacturers will talk about what aspects need to be paid attention to when driving the mixer?
1、在公路上行駛時，加長溜槽須翻轉放置在卸料溜槽上用掛鉤掛牢，再轉至與車身垂直部位，用鎖緊裝置把卸料溜槽和加長溜槽鎖緊在機架上，防止由于不固定而搖動，造成傷人事故和影響其它車輛運行。
1. When driving on the highway, the extended chute must be overturned and placed on the discharge chute, hung firmly with a hook, and then turned to the vertical part with the vehicle body. The discharge chute and the extended chute are locked on the frame with a locking device to prevent shaking due to instability, causing injury accidents and affecting the operation of other vehicles.
2、輸送混凝土的容量，質量及塌落度應符合第二章中的規定。
2. The capacity, quality and slump of transported concrete shall comply with the provisions in Chapter II.
3、攪拌車在露天場地停放時，裝料前應先將攪拌筒反轉，把筒內的積水（或雨水）和雜物卸出，以保證運送混凝土的質量。
3. When the mixer truck is parked in the open air, the mixer drum should be reversed before loading, and the accumulated water (or rainwater) and sundries in the drum should be unloaded to ensure the quality of concrete transportation.
4、在出料斗、卸料溜槽旁工作時，要佩戴防護用品。不要接近料斗及攪拌口，也不要向內窺看，更不得用手去摸旋轉的攪拌筒。
4. Wear protective equipment when working near the discharge hopper and discharge chute. Do not approach the hopper and mixing port, nor look inward, nor touch the rotating mixing drum with your hands.
5、新車開始使用時，須進行全面檢查和試車，一切正常時，方可正式使用。
5. When the new car is put into use, it must be thoroughly checked and tested. It can be officially used only when everything is normal.
6、交貨時，如發現水分蒸發，塌落度偏低不能滿足用戶要求時，可適當向筒內加水，然后以12—14r/min的速度旋轉30轉后卸料。
6. During delivery, if it is found that the water evaporates and the slump is too low to meet the user's requirements, water can be added to the cylinder appropriately, and then rotate at the speed of 12-14r/min for 30 turns before unloading.
7、工作裝置連續運轉時間不應超過8h。
7. The continuous operation time of the working device shall not exceed 8h.
8、車穿越橋、洞、庫等設施時，須注意通過高度的尺寸及路面承受重量以免損壞攪拌車。
8. When the truck passes through bridges, holes, warehouses and other facilities, attention must be paid to the size of the passing height and the weight borne by the road to avoid damaging the mixer truck.
9、攪拌車在空載運行及運送混凝土過程中，攪拌筒不得停止轉動以免滾道、滾輪局部碰損或混凝土產生離析現象。
9. During the no-load operation of the mixer truck and the transportation of concrete, the mixing drum shall not stop rotating, so as to avoid local damage of the raceway and rollers or segregation of concrete.
10、水箱的水量要經常加滿，以備急用。
10. The water tank should always be filled up for emergency use.
以上就是在開攪拌車時，所需要注意的各種事項，為了安全著想，車主需要提前進行了解，且熟練駕駛。更多事項就來我們網站http://m.bflrsn.cn進行咨詢吧。
The above are the various matters that need to be paid attention to when driving the mixer truck. For the sake of safety, the owner needs to understand in advance and drive skillfully. Come to our website for more information http://m.bflrsn.cn Consult.
